Johdanto
This manual provides essential information for the safe and proper installation, operation, and maintenance of your Leviton Commercial Grade Single Receptacle Outlet, Model 5821-W. This 20 Amp, 250 Volt, NEMA 6-20R, 2-Pole, 3-Wire receptacle is designed for commercial and institutional applications, offering durability and reliable performance. Please read all instructions carefully before beginning installation.
Tärkeitä turvallisuustietoja
VAROITUS: Sähköiskun tai tulipalon vaara.
- Katkaise aina virta sulakekaapista tai sulaketaulusta ennen laitteen asentamista tai huoltoa.
- Asennuksen saa suorittaa vain pätevä sähköasentaja kaikkien kansallisten ja paikallisten sähkömääräysten mukaisesti.
- Käytä vain kuparia tai kuparipäällysteistä johtoa. Älä käytä alumiinijohdotuksen kanssa.
- Varmista, että kaikki johtoliitännät ovat tukevasti kiinni ja asianmukaisesti eristettyjä.
- Do not exceed the specified electrical ratings of 20 Amps ja 250 volttia.
- Tämä laite on tarkoitettu vain sisäkäyttöön.
Failure to follow these instructions may result in serious injury, death, or property damage.
Tuote loppuview
The Leviton 5821-W is a commercial specification grade single receptacle outlet. It features a smooth face and is designed for side wiring. The NEMA 6-20R configuration indicates it is a 2-pole, 3-wire grounding receptacle rated for 20 Amps 250 voltilla.
Kuva 1: Etuosa view of the Leviton 5821-W Single Receptacle Outlet, showing the NEMA 6-20R configuration.
Kuva 2: Sivu view of the Leviton 5821-W Single Receptacle Outlet, highlighting the side wire terminals.
Kuva 3: Takaosa view of the Leviton 5821-W Single Receptacle Outlet, showing the robust construction and wiring access points.
Asennus ja asennus
Tarvittavat työkalut: Screwdriver (Phillips and flathead), Wire Strippers, Electrical Tape, Voltage Testaaja.
- Sammuta virta: Paikanna pistorasiaa, jota olet vaihtamassa tai asentamassa, ohjaava sulake tai katkaisija. Kytke se OFF-asentoon. Varmista, että virta on katkaistu äänenvoimakkuuden mittarilla.tage testaaja.
- Irrota vanha pistorasia (jos sovellettavissa): Unscrew the wall plate and then the mounting screws holding the old receptacle in the electrical box. Carefully pull the old receptacle out of the box. Disconnect the wires, noting which wire was connected to which terminal.
- Valmistele johdot: Strip approximately 1/2 inch (12.7 mm) of insulation from the ends of the circuit wires. Ensure the wire ends are clean and straight.
- Kytke johdot: The Leviton 5821-W is a side-wire only device.
- Yhdistä MUSTA or PUNAINEN (hot) wire to the MESSINKI terminal screw.
- Yhdistä VALKOINEN (neutral) wire to the HOPEA terminal screw.
- Yhdistä VIHREÄ or bare copper (ground) wire to the VIHREÄ terminal screw.
- Kiinnitysliitäntä: Carefully fold the wires into the electrical box, leaving enough room for the receptacle. Insert the receptacle into the box and secure it with the mounting screws.
- Asenna seinälevy: Attach the wall plate over the receptacle and secure it with the provided screw(s).
- Palauta virta: Kytke virta takaisin päälle sulaketaulusta tai sulakekaapista.
- Testata: Verify the receptacle is functioning correctly with a suitable device.
Käyttöohjeet
The Leviton 5821-W Single Receptacle Outlet operates by providing a 20 Amp, 250 Volt power connection for compatible NEMA 6-20P plugs. Simply insert the plug of your electrical device into the receptacle. Ensure the plug is fully inserted for a secure connection.
This receptacle is designed for continuous duty within its specified ratings. It does not feature any user-operable controls or indicators.
Huolto
The Leviton 5821-W receptacle requires minimal maintenance. Regular inspection and cleaning are recommended to ensure optimal performance and safety.
- Puhdistus: To clean the surface of the receptacle, first turn off power at the circuit breaker. Use a soft, damp cloth with a mild detergent. Do not use abrasive cleaners or solvents. Ensure the surface is completely dry before restoring power.
- Tarkastus: Periodically inspect the receptacle for any signs of damage, such as cracks, discoloration, or loose connections. If any damage is observed, turn off power immediately and have the receptacle inspected and replaced by a qualified electrician.
- Tiiviys: Over time, wire connections can loosen. If you suspect a loose connection (e.g., flickering power, heat from the outlet), turn off power and have a qualified electrician check and tighten all terminal screws.
Vianetsintä
If you experience issues with your Leviton 5821-W receptacle, refer to the following common troubleshooting steps. Always ensure power is OFF before performing any inspection or repair.
| Ongelma | Mahdollinen syy | Ratkaisu |
|---|---|---|
| Ei virtaa pistorasiassa. | Circuit breaker tripped or fuse blown. Loose wiring connection. Faulty receptacle. | Check and reset the circuit breaker or replace the fuse. Turn off power and check wire connections; tighten if loose. If problem persists, replace the receptacle. |
| Plug does not fit or is loose. | Incorrect plug type (not NEMA 6-20P). Worn receptacle contacts. | Ensure the device plug is NEMA 6-20P. If contacts are worn, replace the receptacle. |
| Pistorasia tuntuu lämpimältä. | Overload. Loose wiring connection. | Reduce the load on the circuit. Turn off power and check wire connections; tighten if loose. If warmth persists, consult a qualified electrician. |
Jos vianmääritysohjeet eivät ratkaise ongelmaa, ota yhteyttä pätevään sähköasentajaan saadaksesi apua.
Tekniset tiedot
| Ominaisuus | Yksityiskohta |
|---|---|
| Merkki | Leviton |
| Malli | 5821-W |
| Tyyppi | Yksittäinen pistorasia |
| Luokka | Commercial Specification Grade |
| Ampkorotus | 20 Amps |
| Voitage | 250 volttia |
| NEMA-kokoonpano | 6-20R |
| Napat/johdot | 2-Pole, 3-Wire Grounding |
| Johdotusmenetelmä | Side Wire Only |
| Materiaali | Nylon |
| Väri | Valkoinen |
| Tuotteen mitat | 12.5"L x 8"W (Note: This dimension seems unusually large for an outlet. It might refer to packaging or a different measurement. Actual device dimensions are typically smaller.) |
| Sertifikaatit | UL Listed 498, CSA Certified, NOM Certified, Meets NEMA WD-1 and WD-6, ANSI Standards |
| UPC | 078477790281 |
Takuu ja tuki
Takuu: This Leviton product is backed by a limited 10-year warranty on parts. For specific terms and conditions, please refer to the warranty documentation included with your purchase or visit the official Leviton websivusto.
Asiakastuki: For technical assistance, product inquiries, or warranty claims, please contact Leviton customer support through their official website or the contact information provided in your product packaging. Always provide the model number (5821-W) when seeking support.
You can visit the official Leviton store for more information: Leviton-myymälä